Opel Astra H 2004 to 2009 2.0 T remap
Standard this engine makes 170hp and 250Nm. Our STAGE 1 file takes it to 200hp and 300Nm.
Where the power arrives
Power and torque through the rev range, on the STAGE 1 file.
- Standard 170hp
- Remapped 200hp
- Standard 250Nm
- Remapped 300Nm
Stages for this engine
Stage 1 needs nothing fitted. Anything above assumes the supporting hardware is on the car already.
Remapping the 2.0 T
The Opel Astra H 2004 to 2009 2.0 T runs a factory calibration built to cope with poor fuel, skipped servicing and hot countries. We rewrite the fuelling, boost and timing for this engine on this car, then test it before you get it back. The original file is kept, so it can go back to standard whenever you want.
On the petrol side the difference shows in throttle response and in how hard it pulls through the top half of the rev range. It feels sharper off idle and keeps going where it used to flatten out.
Figures on this page are for a standard car in good health. We read the fault codes and check the basics first, and if something needs attention we will tell you before we write anything. Have a look at the other engines on the H 2004 to 2009, the full Astra range, or everything we do for Opel.
Other engines on this Astra
H 2004 to 2009 cars.
- 1.7 CDTI80hp standardDiesel
- 1.3 CDTI90hp standardDiesel
- 1.7 CDTI100hp standardDiesel
- 1.9 CDTI 8V100hp standardDiesel
- 2.0 DTI100hp standardDiesel
- 1.7 CDTI110hp standardDiesel
- 1.9 CDTI 8V120hp standardDiesel
- 1.7 CDTI125hp standardDiesel
- 1.9 CDTI 16V150hp standardDiesel
- 2.0 CDTI160hp standardDiesel
- 1.4 T140hp standardPetrol
- 1.6 T180hp standardPetrol
- 2.0 T200hp standardPetrol
- 2.0 T OPC240hp standardPetrol
Similar power, other makes
Cars running about the same standard output, for comparison.
Other Astra generations
Book your Astra
We write and test every file at our Aston workshop, on our own rolling road. Ring us with your reg and we will tell you what your car should make before you commit to anything.