Diesel

BMW 5-Series E60 2003 to 2010 525d remap

Standard this engine makes 197hp and 400Nm. Our STAGE 2 file takes it to 265hp and 550Nm.

+68horsepower
+150newton metres
3stages available

Where the power arrives

Power and torque through the rev range, on the STAGE 2 file.

Power before and after
0721432152861,0001,6502,2752,9253,5754,200 RPM 0721432152861,0002,0253,0504,075hp RPM
  • Standard 197hp
  • Remapped 265hp
Torque before and after
01492974465941,0001,6502,2752,9253,5754,200 RPM 01492974465941,0002,0253,0504,075Nm RPM
  • Standard 400Nm
  • Remapped 550Nm

Stages for this engine

Stage 1 needs nothing fitted. Anything above assumes the supporting hardware is on the car already.

Every figure for the 525d

FilePowerGainTorqueGainPrice
Standard197hpn/a400Nmn/an/a
ECOn/an/a500Nmup 100£550
STAGE 1250hpup 53500Nmup 100£650
STAGE 2265hpup 68550Nmup 150£812

Economy files show no new power figure because they are written for torque and drivability rather than peak output.

Remapping the 525d

The BMW 5-Series E60 2003 to 2010 525d runs a factory calibration built to cope with poor fuel, skipped servicing and hot countries. We rewrite the fuelling, boost and timing for this engine on this car, then test it before you get it back. The original file is kept, so it can go back to standard whenever you want.

Diesels like this one gain most through the middle of the rev range, which is where you actually drive. It pulls from lower down, holds a gear on a hill, and needs fewer downshifts to overtake. Drive it the same way afterwards and the economy usually improves a little.

Figures on this page are for a standard car in good health. We read the fault codes and check the basics first, and if something needs attention we will tell you before we write anything. Have a look at the other engines on the E60 2003 to 2010, the full 5-Series range, or everything we do for BMW.

Book your 5-Series

We write and test every file at our Aston workshop, on our own rolling road. Ring us with your reg and we will tell you what your car should make before you commit to anything.